In the concentration of fruit juices, a portion of the feed is redirected to bypass the evaporator and then mixed with the concentrated product to reintroduce flavor compounds that would have been lost by evaporation. The feed (101 kg/h) contains 13.99% solids, and the desired final product should have 43.31% solids. The outlet to the evaporator contains 76.24% solids. What is the flow rate of the evaporator outlet?- Type your answer in kg/h, 2 decimal places.

Q: QI/ Ammonia gas (A) is diffusing through stagnant N2 (B) under steady-state conditions. The total…

A: Total pressureP=1.013×10 Pa Temperature T = 298 K  Concentration of ammonia at point 1 = Y1 mole…

Q: A mixture containing 42 wt% benzene (B) and 58 wt% toluene (T) is fed to a distillation column at a…

A: Given: Feed to the distillation column F = 100 kg/min; Feed composition of benzene xfB = 0.42 or 42%…

Q: Fish Meal Processing. Fish is processed into fish meal and used as an additional source of protein.…

A:

Q: Calculate the vapour pressure of a spherical water droplet 20 Å in radius at 25 °C. The vapour…

A:

Q: Draw a flowchart of the process, labeling the two feed streams (beans and solvent) and the leaving…

A: Flow rate of feed = 750 kg/h Feed composition, Oil=14.5% (by weight) Insoluble solids=85.5% (by…

Q: a. Is the gas saturated at the given conditions? Justify your answer. b. If the gas is cooled at…

A: Pressure = 2 atm Temperature = 120oC = 393 K Volumetric flowrate = 100 m3/hr = 105 L/hr

Q: %

A: GIVEN The barometer shows the value of 700 mm Hg, the temperature of the dry ball is 55 degrees…

Q: A large volume of pure gas (I) at 3 atm absolute pressure is flowing over a surface from which pure…

A: Given: The total pressure of the gas is Pt = 3 atm The partial pressure of A is PA = 0.3 atm, The…

Q: 8. 2700 kg/hr of an acidic waste effluent stream flows from a process into an in- line mixer, where…

A: Given information: Mass flow rate of acidic (H2SO4) stream, macid = 2700 kg/h Weight percentage of…

Q: On a hot summer day at Tallahassee, FL, the temperature of the outside air is 35oC and the pressure…

A:

Q: A tank contains 1000 L of pure water. Brine that contains 0.05 kg of salt per liter of water enters…

A:

Q: Metrics ): Soap-X was asked by their local wastewater treatment plant to reduce phosphorus discharge…

A: a) molar mass of Na3PO4 = 165 g/mol  Tank cleaning generates Na3PO44 = 3800 gal/yr density of Na3PO4…

Q: Acetic acid vapor (A) - air (B) at 0.7 atm pressure and temperature 30 ° C acetic acid from the…

A: Atmospheric pressure, P=0.7 atm Temperature, T=30°C=(30+273) K=303 K Height of the tank,h= 7 m…

Q: A distillation column separates 10,000 kg/hr of a 50/50 benzene/toluene mixture. The product (D)…

A: following values are given in the question the mass flow rate of feed (F)=10000 kg/hr composition of…

Q: A crystallizer is to produce 500 lbs/h of copperas (FESO4 · 7 H20, 277.85) crystals by cooling a…

A: Given, Mass of product formed, P = 500 lbs/hr The molar mass of the product formed is 277.85…

Q: The flue gas from a furnace goes out with the following composition (dry basis): 12% CO2, 3% O2, 2%…

A: Basis: 100 mol of dry fuel gas Given that: barometric (atmpspheric) pressure Patm = 759 mm Hg,…

Q: A single effect evaporator is fed with 10000 kg/h of weak liquor containing 15% caustic by weight…

A:

Q: Very cold water (5°C) is heated at atmospheric pressure (1 atm) until saturated vapor is formed.…

A: Since we only answer up to 3 sub-parts, we’ll answer the first 3. Please resubmit the question and…

Q: 5.00 L of liquid methanol (CH3OH) is placed in a sealed chamber at 25 °C. Dimensions of the chamber…

A: Given, Volume of liquid methanol is 5.00 L density of methanol, ρ = 0.792 g/cm3   Calculate the mass…

Q: Example 3.8: A rectification column is fed 100 kg mol/h of a mixture of 50 mol % benzene and 50 mol…

A: A mixture of benzene and toluene is separated into distillate and bottom products in a distillation…

Q: Five thousand lb/h of wet isophthalic acid crystals with 30 wt% moisture (wet basis) at 30oC and 1…

A:

Q: Spray drying is a process in which a liquid containing dissolved or suspended solids is injected…

A: The production rate of dried milkThe volumetric flow rate of the inlet air.Estimate the upward…

Q: 5.00 L of liquid methanol (CH3OH) is placed in a sealed chamber at 25 °C. Dimensions of the chamber…

A: At liquid-gas equilibrium, a liquid with different concentrations has equilibrium vapor whose…

Q: An aqueous solution of sodium chloride containing 0.2 wt% NaCl and 99.8% water is fed at a rate of…

A: Given,

Q: 1. A bubble cap tray column with 15 trays was designed for the removal of ammonia, the pollutant,…

A: Note: We are authorized to answer three subparts at a time, since you have not mentioned which part…

Q: 360 kg/h of sliced fresh potato (74.51% moisture, the balance is solids) is fed to a forced…

A: Given data: Amount of sliced fresh potato=360 kg/hmoisture inlet=74.51%T=62°CRelative humidity…

Q: Outside air must be processed before entering the ventilation system of a sauna. Air always exits…

A: Given information:   Exit air specifications: Temperature, T2­ = 25°C Pressure, P2 = 1 atm Relative…

Q: A 30,000 L vessel originally charged with air at ambient conditions (1 atm, 25 oC) is required to be…

A: Given data: Volume of vessel; V=30000 LInitial Pressure; Pi=1 atm=760 mm HgInitial mole fraction of…

Q: Assuming the equivalent of 1 tablespoon of acetone was left on the sides of the inverted 44-gallon…

A: ACETONE commonly known as propanone, is a colorless liquid that is used as a solvent in the…

Q: 13. 5.00 L of liquid methanol (CH3OH) is placed in a sealed chamber at 25 °C. Dimensions of the…

A: Given, Volume of liquid methanol is 5.00 L density of methanol, ρ = 0.792 g/cm3   Calculate the mass…

Q: The moisture content of a solid is reduced to 8% from 30% in the unit diagrammed below. Some of the…

A: a) The product flow rate P =? Refer to the figure shown below for the given information,

Q: ank initially filled with fresh water has a mixture of salt and insoluble material at its bottom. If…

A:

Q: Q3/ Potassium nitrate solution (F) containing 19 wt. % KNO3 are continuously fed to the process…

A:

Q: Outside air must be processed before entering the ventilation system of a sauna. Air always exits…

A: Given information:   Exit air specifications: Temperature, T2­ = 25°C Pressure, P2 = 1 atm Relative…

Q: single effect evaporato

A:

Q: An aqueous solution of sodium chloride containing 0.2 wt% NaCl and 99.8% water is fed at a rate of…

A:

Q: Your boss asks you to calculate the flow through a natural-gas pipeline where the gas is at a…

A: You need to balance the components to estimate the flow ratea ) calculation for the first…

Q: and the mixture is heated to evaporate water. The residue has 1/3 water by mass. a) Calculate the…

A:

Q: Q6/ Breakfast cereal is being dried in a fluidized bed dryer in which the cereal moves roughly…

A: Given Cereal is dried in fluidized bed with the help of air flow counter currently Cereral=14%…

Q: An evaporator is a unit operation that concentrates a liquid solution by evaporating pure water as…

A:

Q: spray

A:

Q: A manufacturing process uses the powerful solvent acetone. One phase of the process is to dry out…

A: Given data: Evaporation rate of acetone = 2 gallon/h Every gallon of liquid acetone produces 41 ft3…